7 recalls and 641 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2003 Volkswagen Passat sedan, Jetta, Jetta wagon, Golf, EuroVan, EuroVan Camper Van and EuroVan Chassis vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator, free of charge. The recall began May 2, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69X3.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Remedy: Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
ON CERTAIN VEHICLES EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 20007. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834. THIS RECALL IS A SUPPLEMENT TO A PREVIOUS CAMPAIGN (PLEASE SEE 06V017).
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
ON CERTAIN VEHICLES PRODUCED FROM SEPTEMBER 2002 - MARCH 2003, EQUIPPED WITH 1.8L TURBO, 2.8L V6, OR 3.0L ENGINES, A CHANGE IN THE ELECTRICAL MOTOR COMPONENTS IN THE FUEL PUMP CAN LEAD TO AN INOPERATIVE FUEL PUMP AND, ULTIMATELY, STOPPAGE OF FUEL SUPPLY TO THE ENGINE CAUSING IT TO STALL.
Remedy: DEALERS WILL INSTALL NEW FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT VW AT 1-800-222-8987 OR AUDI AT 1-800-822-2834.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
If the front passenger airbag is deployed as a result of an accident, the gas generator housing may burst or components of the gas generator housing may come loose and cause serious or fatal injuries to vehicle occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The propellant in the driver airbag may deteriorate over time. If the airbags deploy, it can result in fragments from the inflator injuring the vehicle's occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The propellant in the driver airbag may deteriorate over time. If the airbags deploy, it can result in fragments from the inflator injuring the vehicle's occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The propellant in the driver airbag may deteriorate over time. If the airbags deploy, it could result in fragments from the inflator injuring the vehicle's occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The driver airbag's gas generator may be faulty, resulting in uncontrolled inflation and the release of metal fragments. This increases the risk of injuries to the occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Cars initially used for internal purposes of Volkswagen AG might not have been correctly modified before they were sold to the general public. There is a possibility that certain safety systems of these cars are not correctly modified for street use. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The thermal protection between the brake force booster and the emissions control device in front of the coupling support with the brake fluid reservoir may not have been correctly fitted. The coupling support could melt, leading to a leak of brake fluid, which could ignite if it comes into contact with hot components. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Matched on brand and model name — Safety Gate publishes no VIN. Check the production dates, and quote the recall code to a dealer.
BRAKE FAILURE LIGHT APPEARS EVEN AFTER MULTIPLE BRAKE REPAIRS. DRIVER?S SIDE REAR UPPER BRAKE LIGHT REPLACED FOR 29TH TIME IN LESS THAN 2 YRS. MULTIPLE COOLANT LEAKS STILL PRESENT EVEN AFTER REPAIR AND WATER PUMP REPLACEMENT. RADIO/AMPLIFIER NOT FUNCTIONING EVEN AFTER REPLACEMENT (RADIO WAS ONLY USED TWICE IN VEHICLE?S LIFETIME). DIAGNOSTICS SHOW AIRBAG MALFUNCTION. REGULATOR PIN ON REAR PASSENGER SIDE WINDOW KEEPS BREAKING (3RD REPLACEMENT SINCE 2003). ENGINE COVER BELOW CAR KEEPS FALLING OFF DUE TO RUSTED BOLTS. HOMELINK SYSTEM KEEPS MALFUNCTIONING. FUSES KEEP BLOWING OUT. DASHBOARD PANEL LIGHTS OUT (ODOMETER, FUEL GAUGE, ETC.). CCM MODULE KEEPS BREAKING DOWN. CAR NEEDS TO BE JUMPSTARTED WHEN NOT IN USE FOR OVER 48 HRS. CLIMATE CONTROL (A/C AND HEATER) WORKS ONLY SPORADICALLY. ALL REPAIRS PERFORMED BY VW DEALERSHIP, YET SAME ISSUES KEEP REAPPEARING JUST A FEW WEEKS AFTER REPAIRS. REPAIRS PERFORMED IN PAST 2 YEARS: ECU UNIT REPLACED, BRAKE LIGHT SWITCH REPLACED 3 TIMES, A/C COMPRESSOR UNIT REPLACED, ABS MODULE REPLACED, ALTERNATOR REPLACED, BRAKES REPLACED 3 TIMES. *TR
MY SON WAS DRIVING (IN MOTION) ON HWY 17 IN MILLER COUNTY MO WITH SEAT HEATER ON SATURDAY NOV. 28, 2020. SEAT CAUGHT ON FIRE. I HAD NOTICED WHEN I HAD SEAT HEATER ON PREVIOUSLY IT BECAME SO HOT AS TO BURN LEGS. THIS IS A SERIOUS PROBLEM. IT COULD HAVE BURNED MY CAR COMPLETELY. VERY DANGEROUS.
MY FRONT DRIVER SEAT WARMER WAS TURNED ON LOW. I COULD FEEL THE SEAT GETTING WARMER AND CHECKED TO BE SURE THE SETTING WAS NOT ON HIGH WHICH IT WASN'T. I THOUGHT MAYBE I WAS BEING SENSITIVE AND STUCK MY MITTEN UNDER MY THIGH. I THEN NOTICED A FUNNY SMELL AND SUDDENLY THINGS GOT VERY HOT AND STARTED TO BURN MY LEG AS I WAS DRIVING. I LOOKED DOWN AND ACTUALLY STARTED TO SEE SMOKE. I WAS NOT ABLE TO JUST PULL OVER BUT QUICKLY TURNED THE SEAT OFF. I PULLED OUT MY MITTEN AND FLEECE WAS ACTUALLY MELTED. I WAS A BLOCK OR TWO FROM WORK AND TRIED TO KEEP FROM SITTING COMPLETELY DOWN AS IT BURNED. I ARRIVED AND JUMPED OUT TO SEE A BLACKENED AREA AND HOLE IN MY SEAT!! THE CAR WAS SMELLING AND I AM STILL IN SHOCK OVER THIS. I HAVE LOOKED AND CAN'T FIND A RECALL ON THE SEAT. THIS IS VERY DISTURBING AND DANGEROUS. THIS SHOULD NOT HAPPEN NO MATTER HOW OLD THE CAR IS.
TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD AND POURING INSIDE THE VEHICLE. THE CONTACT FOUND WATER AND COOLANT LEAKING FROM THE DASHBOARD AND ONTO THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS ALSO OVERHEATING. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED FLAMES COMING FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE HOWEVER, THE CONTACT SUSTAINED BURNS TO HER LEGS DUE TO THE HOT LEAKING COOLANT. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE ENGINE BLEW AND THE INSTRUMENT PANEL CLUSTER WAS DAMAGED. THE CONTACT WAS UNAWARE OF WHAT CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 174,256.
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE HEATED SEAT FEATURE ACTIVATED, THE CONTACT NOTICED THAT THE HEATER BURNED THROUGH THE SEAT AND THROUGH HIS CLOTHING. HIS LEG WAS BURNED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE HEATED SEAT MOTOR NEEDED TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 102,500.
TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 45 MPH ON NORMAL ROAD CONDITIONS, THE DRIVER'S HEATED SEAT CONTROL MODULE WAS ACTIVATED. A HIGH VOLTAGE OF HEAT PENETRATED THROUGH THE BOTTOM OF THE SEAT AND SMOKE SUDDENLY APPEARED. THE DRIVER DEACTIVATED THE HEATED SEAT CONTROL MODULE. HE BURNED HIS FINGER ON THE SEAT. THE AUTHORIZED DEALER WAS NOTIFIED OF THE MALFUNCTION. THE MANUFACTURER'S CUSTOMER SATISFACTION CAMPAIGN M2 WAS REFERENCED. THE FREE REMEDY CONSISTED OF INSTALLING A REPAIR KIT FOR THE HEATED SEAT. THE REMEDY WAS PERFORMED ON THE VEHICLE IN 2005; HOWEVER, IT WAS INSUFFICIENT AND DID NOT PREVENT FUTURE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 76,900 AND CURRENT MILEAGE WAS 77,000.
A THIRD IGNITION COIL FAILURE IN 18 MONTHS, THE LAST ONE ALLOWING RAW GASOLINE INTO THE CATALYTIC CONVERTER, WHERE IT CAUGHT FIRE, DESTROYING THE TURBO AND CAUSING A LARGE AMOUNT OF BLACK SMOKE. I LOST POWER WHILE DRIVE, WAS UNABLE TO ACCELERATE IN A SAFE MANNER AND EVENTUALLY SUFFERED SMOKE INHALATION. ALL COILS NEED TO BE REPLACED. *TR
NORMAL OPERATION OF AUTOMOBILE, DRIVERS SIDE SEAT HEATER PLACED ON SETTING LEVEL 2. FIRE BEGAN WITHIN THE DRIVERS SIDE SEAT AND BURNT A QUARTER SIZE HOLE THROUGH THE FABRIC OF THE SEAT. *TR
DRIVER WAS ON DAILY COMMUTE TO WORK, STOPPED AT AN INTERSECTION. A LOUD BANG WAS HEARD BY THE DRIVER AND WHEN THE DRIVER EXITED THE CAR TO SEE WHAT HAD HAPPENED, A BYSTANDER IMMEDIATELY YELLED TOWARD THE DRIVER TO WARN THEM THAT THE CAR WAS ON FIRE. DRIVER WAS ABLE TO MAKE IT OUT OF CAR SAFELY, WITH MINOR INJURIES INCURRED AS A RESULT OF TRYING TO PUT OUT THE FIRE. THE FIRE ITSELF WAS LIMITED TO THE ENGINE COMPARTMENT, HOWEVER AS A RESULT THE ENTIRE ENGINE AND ENGINE COMPARTMENT WERE DESTROYED AND THE CAR WAS CONSIDERED A TOTAL LOSS BY INSURANCE. SINCE THE DEFECTIVE COMPONENT(S) AND SURROUNDING AREA INVOLVED IN THE DEFECT WERE COMPLETELY DESTROYED, THERE WAS NO PARTS TO REPAIR OR REPLACE. *JB
WAS USING THE HEATED DRIVERS SEAT AS I WAS DRIVING DOWN THE HIGHWAY IN COLD WEATHER. THE SEAT BEGAN TO OVERHEAT, CAUGHT ON FIRE, BURNED A HOLE IN MY PANTS, AND BURNED THROUGH THE PADDING AND SEAT FABRIC IN MY 2003 VW PASSAT. I QUICKLY TURNED OFF THE SEAT AND PULLED OFF THE HIGHWAY AS SOON AS POSSIBLE, AND PUT OUT THE SMOLDERING SEAT. THE SEAT, PADDING, HEATING ELEMENTS, AND MY PANTS ARE COMPLETELY RUINED. *JB
DT*: THE CONTACT STATED THE FRONT DRIVER SEAT'S HEATER ELEMENT BURNED THROUGH THE SEAT AND CAUGHT THE CONTACTS CLOTHES ON FIRE. THE CONTACT SUSTAINED BURNS TO THE LEGS. THE VEHICLE WAS TAKEN TO A SERVICE DEALER. UPDATED 12/01/06. *JB
WHILE MY HUSBAND WAS DRIVING OUR 2003 AWD PASSAT WAGON WITH MYSELF AND TWO CHILDREN IN THE CAR, THE DRIVER SEAT CAUGHT ON FIRE. AT THE TIME IT CAUGHT FIRE, THE HEATED SEAT WAS ON SETTING 3 FOR NO MORE THAN 5 MINUTES. LUCKILY, MY HUSBAND WAS ABLE TO PULL OFF THE ROAD, EXIT THE VEHICLE, AND TURN OFF THE HEATED SEAT BEFORE HE WAS BURNED AND/OR A LARGE FIRE ERUPTED. *NM
WHILE DRIVING WITH HEATED SEATS ON, NOTICED BURNING IN MY LEFT THIGH. SMELLED SMOKE, BURNED MY INDEX FINGER IN SMOLDERING HOLE IN SEAT. TURNED OFF HEATER AND NOTED JUST LIGHT SMOKE. VW SAYS IT WAS A RECALL ITEM, BUT I NEVER RECEIVED NOTICE (ORIGINAL OWNER). THEY WILL REPLACE IT. *JB
I DRIVE A 2003 VW PASSAT AND WHILE DRIVING A TWO LANE ROAD THE SEAT HEATER INSIDE THE LEATHER SEATS IGNITED BURNING THROUGH THE SEAT, BURNING A HOLE IN MY PANTS AND BURNING MY BEHIND CAUSING ME TO SWERVE OFF THE ROAD AND EXIT THE VEHICLE TO AVOID OTHER INJURY AS THE SEAT BURNED. THIS HAS BEEN APPARENTLY REPORTED HUNDREDS OF TIMES YET VW REFUSES A RECALL. VW AGREED TO REPLACE THE SEAT AND PANTS BUT REFUSED ANY OTHER COMPENSATION FOR INJURIES SUSTAINED. *JB
DRIVERS SEAT CAUGHT ON FIRE WITHIN 30 SECONDS OF STARTING VEHICLE, LEFT CIGARETTE SIZE BURN HOLE IN SEAT, DRIVERS PANTS, AND LEFT BURN MARK ON DRIVERS BUTTOCKS. *NM
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.