2005 Ford F-250
1 recall and 144 owner complaints on record for this model year.
Check a specific vehicle
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VIN1 recall and 144 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES. THE RIMS PROVIDED IN THESE WHEEL MODIFICATION GROUPS WEAR THROUGH THE OEM BRAKE LINES.
Remedy: HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
THE 2005 FORD F250 PICKUP TRUCKS HAS AN ISSUE WHILE FILLING VEHICLE WITH FUEL. THE FUEL SHOOTS OUT OF GAS TANK FILL INLET DURING THE FUELING PROCESS. THIS PROBLEM WILL HAPPEN WITH THE FUEL GAUGE REGISTERING EMPTY, HALF, OR NEAR FULL. I HAVE HAD GAS SHOOT ALL OVER ME AND OTHER PEOPLE TIME AND TIME AGAIN. I HAVE BEEN INSTRUCTED TO NOT GET GAS IN THAT TRUCK AT EVERY GAS STATION NEAR MY HOME. I HAVE TO DRIVE ACROSS TOWN TO GET GAS. AS SOON AS THEY NOTICE FUEL SPILLING OUT OF MY TRUCK, I WILL BE BANNED FROM THEIR STATIONS TOO. THERE ARE 8 GAS STATIONS WITHIN 5 BLOCKS THAT HAVE BANNED ME. IT COSTS ME APPROX. $4 TO GO GET FUEL, EVEN THOUGH THERE IS A STATION 1 BLOCK AWAY. I CONTACTED FORD CUSTOMER SERVICE MANY TIMES. THEY CLAIM IT ISN'T A RECALL ISSUE. I RESEARCHED THE FORD EXECUTIVES COMPANY EMAIL ADDRESSES AND SENT EMAILS TO THEM. THE EMAIL ADDRESSES WERE STILL VALID AND NOT RETURNED. THE EMAILS MADE IT TO THOSE EXECUTIVES BUT THEY NEVER RESPONDED. I EXPLAINED THAT THE FUEL SPILLAGE IS CAUSING A HUGE SAFETY CONCERN AND MAY KILL ME OR SOMEONE ELSE. I EXPLAINED THAT THE PROBLEM MAY CAUSE AN EXPLOSION AT A STORE. THE FORD MOTOR SERVICE PROFESSIONALS HAVE TOLD ME THAT THE FILTER IN THE TANK HAS GONE BAD. I HAVE MADE THE COSTLY REPAIR 4 TIMES SINCE MAY OF 2008. IT WORKS WELL FOR A FEW MONTHS AND THEN THE GAS SHOOTS OUT AGAIN. ON ONE OF THOSE INSTANCES, THE FUEL SPILLED OUT, AND I FINISHED FUELING AND PULLED TO THE FRONT OF THE STORE TO REPORT THE SPILLAGE. SOMEONE DROVE UP IN THAT SPOT SMOKING A CIGARETTE AND CAUSED A FIRE FROM THE FUEL SPILLED AT THE PUMP. I WAS BANNED FROM THAT STORE AS WELL. I HAVE TO EITHER PAY FOR A COSTLY GAS TANK FUEL FILTER REPLACEMENT, GET BANNED FROM STORES FOR HONESTLY REPORTING THE SPILLAGE, OR FUEL UP AND DRIVE AWAY FROM THE STORE BEFORE SOMEONE NOTICES THAT I SPILLED FUEL. I DON'T LIKE DOING ANY OF THOSE THINGS. FORD DOESN'T CARE. *TR
TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT UPON START-UP. THE FAILURE WAS RECURRING. THE STARTER WOULD TURN OVER BUT THE ENGINE WOULD NOT ENGAGE. THE BATTERY WAS REPLACED TWICE BUT TO NO AVAIL. ADDITIONALLY, BLACK SMOKE WAS EMITTING FROM THE VEHICLE AND THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109000.
TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT SHE SMELLED A BURNING ODOR AND NOTICED THAT THERE WAS NO WATER IN THE RADIATOR UNIT. SHE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE EGR COOLING UNIT AT THE COST OF $1,100. THE TECHNICIAN STATED THAT ON THIS PARTICULAR MODEL VEHICLE HE MAKES AT LEAST TWO REPAIRS A DAY IN REFERENCE TO THIS COMPONENT. IMMEDIATELY AFTER THE REPAIR, THE CONTACT SMELLED AN ODOR IDENTICAL TO ANTIFREEZE FLUID, AND NOTICED THAT THE RADIATOR DID NOT HAVE ANY WATER IN IT ONCE AGAIN. SHE IS IN THE PROCESS OF HAVING THE VEHICLE RE-INSPECTED. THE CONTACT EMAILED THE MANUFACTURER AND A REPRESENTATIVE RESPONDED BY DENOUNCING ANY RESPONSIBILITY FOR HER FAILURE. THE REPRESENTATIVE ALSO STATED THAT IT WAS NOT A MANUFACTURER DEFECT. THE FAILURE AND CURRENT MILEAGES WERE 108,000.
I STARTED THIS TRIP AT THE KENTUCKY HORSE PARK, I-75 AT EXIT 120. I HAD BEEN DRIVING AN HOUR, HEADING NORTH. THIS INCIDENT TOOK PLACE LATE AFTERNOON, BETWEEN 5PM AND 6PM, BROAD DAYLIGHT EXCELLENT VISIBILITY, DRY, PARTLY CLOUDY, TRAVELING 65 MPH IN THE CENTER OF THREE LANES. I WAS NOT TIRED NOR DISTRACTED. I WAS NORTHBOUND ON I-75 IN NORTHERN KY WHEN I WENT OVER A MINOR BUMP, JUST ROUGH PAVEMENT. I AM ABSOLUTELY CERTAIN THERE WAS NO OBJECT IN THE ROAD. AFTER THE BUMP THE TRUCK BEGAN STEERING ERRATICALLY, WANDERING, MUCH AS IT HAD 4 DAYS EARLIER WHEN I TOOK IT TO MY FORD DEALER AND THEY REPLACED THE FRONT U-JOINTS. I SLOWED DOWN, GOT THE TRUCK UNDER CONTROL, TURNED OFF THE CRUISE CONTROL, AND MOVED TO THE RIGHT LANE. I HEARD A HIGH-PITCHED SCREECHING METAL NOISE. THEN I SMELLED BURNING RUBBER. I WAS ALERT AND VERY AWARE OF ROAD CONDITIONS AND THE TRAFFIC (TWO LANES WERE MERGING FROM THE RIGHT FROM I-275 SO I WAS IN THE CENTER OF FIVE LANES) AND I AM CERTAIN THERE WERE NO OBJECTS IN THE ROAD. THE CONCRETE WAS CLEAR AND SMOOTH. I HEARD A LOUD BANG UNDER THE RIGHT FRONT OF THE TRUCK AND IT TOOK OFF TO THE RIGHT. IT WAS IMMEDIATELY CLEAR THE TRUCK WAS NOT RESPONDING TO THE STEERING WHEEL. I PUT BOTH FEET ON THE BRAKE PEDAL, MADE MY BODY RIGID AND PULLED UP ON THE STEERING WHEEL FOR MAXIMUM DOWN FORCE ON THE BRAKE PEDAL. COMPLETELY OUT OF CONTROL, I TRAVELED ACROSS BOTH LANES ON MY RIGHT (THE MERGING LANES FROM I-275) AND CAME TO A STOP WITH THE LEFT REAR WHEEL ON THE CONCRETE APRON AND ALL OTHER WHEELS IN THE ROCKY SOIL THAT WAS THE SIDE OF A DITCH WITH A MOUNTAIN ON THE OTHER SIDE. IT WAS LATER DETERMINED THAT THE TIE ROD END HAD SNAPPED. ONE THEORY IS THAT THE TIE ROD END WAS OVER-HARDENED AND BECAME BRITTLE, POSSIBLY CRACKED, THEN THE NEW U-JOINTS CHANGED THE STRESSES ON IT AND IT SNAPPED. INSURANCE REPORT, CRASH SITE AND PARTS PHOTOS AVAILABLE ON REQUEST. *TR
TL*THE CONTACT OWNS A 2005 FORD F-250 SUPER DUTY. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED; HOWEVER, IT CONTINUED TO MOVE FORWARD UNTIL IT CRASHED. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE FUEL INJECTOR CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALSO NOTIFIED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V266000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,568 AND THE CURRENT MILEAGE WAS 54,568.
TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 55 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. THE CONTACT SLOWED THE VEHICLE DOWN AND THE TIRES BLEW OUT. THE VEHICLE VEERED TO THE LEFT AND INTO ONCOMING TRAFFIC. THE CONTACT CRASHED INTO A MOUNTAIN AND THE VEHICLE ROLLED OVER TWICE. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 65,197.
Odometer Fraud. The contact owns a 2005 Ford F-250. The contact purchased the vehicle from a private seller on social media. The contact stated that the sellers advertisement indicated the odometer mileage was 96,000. The contact later purchased a new vehicle and decided to sell the existing vehicle. The existing vehicle was posted on social media for sale. A potential buyer noticed the vehicle and obtained a Carfax report. The potential buyer then sent a copy of the Carfax report to the contact. The Carfax report indicated that the odometer was reported at 303,000 in 2023. The contact then contacted the seller and informed the seller of the discrepancy. The contact was informed that the odometer had been swapped prior to the sale. The contact stated that seller then deleted the advertisement from social media and rejected all further communications with the contact.
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue
While driving at 65 Mph, towing a fifth wheel camper, encountered a mildly rough section of highway when entire front end began to wobble and shake violently. Slowed the vehicle, maintaining control. When going back up to speed, the same shaking occured again. Also noted a less violent shaking at 45 mph. Took vehicle to have new tires rebalanced but did not change condition much. Inspected front end components. Currently replacing steering damper and shocks in hopes of correcting issue. All other components new or nearly new (3 years) with no issues. Vehicle and components can be inspected, and all replaced parts will be kept for inspection if required. Safety of my vehicle and others on busy highway could have been compromised had I not slowed and maintained control. The problem is being dealt with by me, as I do most maintenance on vehicle. The vehicle has not been seen or inspected by others except by tire mechanic who noted no obvious issues but did re-balance all tires. There was NO advance warning of a failure or compromise.
The contact owns a 2005 Ford F-250. The contact stated while driving at an undisclosed speed, the contact heard a loud rumbling noise that sounded like rocks in the engine. In addition, the contact stated that when the vehicle was parked and the engine was turned off, the vehicle was started, however, the vehicle did not start. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that her husband was an independent mechanic and had recently replaced several unknown parts, however the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was 246,808.
Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road
The back bed rails rot/rust very quickly and trying to buy new beds run 4500$ along with o2 sensors ir intake sensors go out of blue no reasoning let alone the power steering lines rusting very very quickly
The tire is a Cooper (Discoverer/Rigged Trek) 35x12.50R20LT. The tire is unreadable as it ripped off the bead. While driving, a sudden pop suddenly occurred and smoke began to appear. I pulled over and realized the entire tire popped/blew up. No accident, it was at 35mph approximately. The vehicle has not been inspected yet as I am typing this while waiting for a tow truck.
In 2014, I got the “Ford death wobble” in the right front. VERY scary and dangerous. Trying to quickly slow down to stop it in traffic is almost as dangerous as the wobble itself. You have very little to no control with the steering when it happens. I had to repair the problem out of pocket because Ford won’t do anything about it. Now, two weeks ago, I had the same death wobble happen at 70 mph on the left front. So frightening. My passengers thought we had a blowout and we’re about to crash. I successfully slowed it down but this problem is a road hazard to me and everyone else on the road. So now, once again, it’s on me to shell out to fix a problem that should have been a recall a long time ago but Ford won’t step up and do the right thing. Please give us some relief here.
towing a trailer, traveling at 70 mph, I hit a pothole and vehicle violently shook. The episode lasted for approx 30 seconds. It was very Difficult to maintain control and I almost ran off the road. It happened several times before I took it for repairs. The stabilizer bar was replaced, however the violent shaking has still continued.
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.