5 recalls and 103 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
Remedy: Dorman will notify owners, and dealers will replace the steering shaft, free of charge. The recall began on October 28, 2015. Owners may contact Dorman customer service at 1-800-523-2492, option 5.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.
Remedy: DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
ON CERTAIN NATURAL GAS MODEL VEHICLES, A T-FITTING THAT CONNECTS FUEL TANKS #3 AND #4 CAN DEVELOP A LEAK WHEN THE SOLENOID VALVES ARE ENERGIZED, SUCH AS WHEN THE IGNITION SWITCH IS IN THE ON POSITION OR DURING REFUELING.
Remedy: DEALERS WILL INSTALL A REDESIGNED "T" FITTING ON #4 FUEL TANK AND TESTED FOR LEAKAGE. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.
Remedy: FORD HAS ADVISED US THAT SHIELD KITS HAVE BEEN AVAILABLE SINCE LATE OCTOBER AND WILL BE INSTALLED ON POLICE INTERCEPTOR VEHICLES AT NO COST. THE OPTIONAL TRANK PACKAGE WILL BE AVAILABLE BY THE END OF 2002. FORD HAS ESTABLISHED A NEW WEB SITE AT WWW.CVPI.COM TO ANSWER ADDITIONAL QUESTIONS ABOUT THE SAFE USE OF CPVI VEHICLES.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
DURING A FRONT END VEHICLE COLLISION AT 40 MPH, THE FRONT AIR BAGS DID NOT DEPLOY. THE CONSUMER SUFFERED MINOR INJURIES. PLEASE PROVIDE MORE INFORMATION. *JB
I PURCHASED A 2002 FORD WINDSTAR 4 DOOR VAN, AND UPON IMPACT OF CRASHMY FRONT AIRBAGS DID NOT DEPLOY. THIS IMPACT WAS AT 50-55MPH. I WAS TOLD THE REASON MY AIRBAGS DID NOT DEPLOY WAS DUE TO MY SEATBELT LOCK WHICH BROKE FROM THE IMPACT. ALSO NOW MY TRANSMISSION IS STALLING AFTER THE REPAIRS WERE MADE BUT THEY SAY NO RECALLS HAVE BEEN MADE ON THIS PROBLEM EITHER, BUT ACCORDING TO MY INSURANCE COMPANY IT IS A PROBLEM NOT ONLY WITH MY VEHICLE BUT SEVERAL OTHER PEOPLE HAVE REPORTED TOO.
AIR BAG DID NOT DEPLOY ON DRIVERS SIDE OF CAR AFTER COLLISION, CHEST INJURES RESULTED, CAR TOTALED. *JB
LOWER RIGHT BALL JOINT FAILURE UNDER NORMAL OPERATION. *JB
TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT OPENED THE HOOD, BUT IT FAILED TO OPEN AUTOMATICALLY. HE PLACED HIS HAND ON THE FENDER AND THE HOOD SUDDENLY FELL AND SLAMMED DOWN ON HIS HAND. THE CONTACT SUSTAINED SEVERAL BRUISES, CUTS, AND BLISTERS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 56,000. UPDATED 03/18/08. *LJ THE CONSUMER STATED AT THE TIME OF THE INCIDENT THE HOOD WAS RAISED TO THE FULL CAPACITY AND VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED STRUTS WERE REPLACED AT CONSUMER'S EXPENSE. UPDATED 03/18/08 *TR UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR
ALL FOUR WHEELS BEARINGS ON A 2002 FORD EXPLORER WITH ONLY 70,000 MILES HAD TO BE REPLACED. ONE INCIDENT INCLUDED A WHEEL FALLING OFF DUE TO THE FAILURE OF THESE BEARINGS. *TR
DT*: THE CONTACT STATED THAT THE SPARE TIRE CABLE BRACKET THAT HOLDS UP THE SPARE TIRE FRACTURED AND COMPLETELY DETACHED. THE SPARE TIRE DROPPED FROM THE VEHICLE AND WAS HIT BY ANOTHER VEHICLE. THE DEALER AND THE MANUFACTURE WAS ALERTED BUT THE MANUFACTURER DENIED THE CLAIM.*AK
IN MID APRIL 2005, AS I WAS DRIVING MY 2002 FORD EXPLORER HOME (HAD@32,000 MILES), THE CAR JUST DIED WITHIN 2 SECONDS. NO WARNING AT ALL. I LOST ALL POWER, THE STEERING WHEEL TIGHTENED AND THAT WAS IT. FORD TOWED THE CAR (AS IT WAS STILL UNDER WARRANTY) AND SAID THAT THE FUEL PUMP WENT AND THAT CAR SHOULD NOT HAVE EVEN STARTED FOR ME. THANK GOD MY 3 YOUNG CHILDREN WERE NOT IN THE CAR WITH ME AND THAT I WASN"T HIT FROM BEHIND. AFTER THEY "FIXED " THE CAR AND AFTER WE PAID $600 FOR A 30,000 MILE MAINTENANCE, 6 WEEKS LATER THE SAME THING HAPPPENS TO MY HUSBAND. HE'D JUST DRIVING ALONG, THE CAR LOSES POWER WITHIN SECONDS AND COMPLETELY DIES WITHOUT ANY WARNING OR EVEN ANY TIME TO PULL OVER TO THE SIDE OF THE ROAD!!! (THE CAR NOW HAS 33,500 MILES). IT IS CURRENTL STILL AT THE DEALERSHIP BEING "FIXED". EE FEEL LIKE WE'VE ESCAPED SERIOUS ACCIDENTS TWICE NOW, AS WE COULD HAVE SO EASILY BEEN HIT FROM BEHIND BOTH TIMES. NEEDLESS TO SAY, WE WILL NEVER PURCHASE ANOTHER FORD AGAIN.
I HAD DRIVEN UP A STEEP MOUNTAIN DIRT ROAD TO SERVE SOME LEGAL PAPERS, AFTER REACHING THE TOP, I CONTINUED DOWN THE OTHER SIDE TO THE ADDRESS I WAS LOOKING FOR. I THOUGHT I STARTED SMELLING SOMETHING BURNING, IT SMELLED ELECTRICAL. WHEN I ARRIVED AT THE ADDRESS, I STOPPED THE CAR AND SHUT IT OFF WHILE I WAS SPEAKING WITH THE RESIDENT. MY WIFE YELLED AT ME THAT THE CAR WAS ON FIRE, IT STARTED FILLING UP WITH SMOKE FAST, MY WIFE AND DOGS WERE STILL IN THE CAR. I OPENED THE DRIVERS DOOR TO POP THE HOOD WHILE MY WIFE STARTED GETTING THE DOGS OUT, I THEN NOTICED IT WAS MY FLOOR THAT WAS BURNING, JUST ABOUT UNDER THE GAS PEDDLE, A HOLE HAD BURNED THROUGH AND THE METAL WAS GLOWING RED WHERE THE PADDING HAD BURNED AWAY. I POURED A CUP OF COFFEE TO PUT THE FIRE OUT WHILE THE RESIDENT GOT SOME WATER FOR ME. THE PADDING AND RUBBER MAT HAD BURNED AWAY AND A HOLE ABOUT 3 INCHES LONG HAD MELTED AWAY FROM THE FLOOR BOARD. THE CATALYTIC CONVERTER IS DIRECTLY BENEATH THE HOLE BUT THERE DOESN'T SEEM TO BE ANY HOLES IN THE CONVERTER AND THERE IS A EMPTY SPACE ABOUT 1.5 - 2 INCHES FROM THE MELTED HOLE TO THE CONVERTER. WE LET EVERYTHING COOL DOWN BEFORE DRIVING HOME, HOWEVER THE ENTIRE WAY HOME, (49 MILES) WE WERE AFRAID THE CAR WAS GOING TO BURST INTO FLAMES. ONCE WE WERE BACK ON THE PAVED ROADS AND WERE ABLE TO DRIVE THE NORMAL SPEED LIMIT, THERE WERE NO MORE ISSUES NOR ANY FURTHER BURNING, JUST THE LINGERING SMELL. I LOOKED UP AND FOUND A RECALL FOR AN ISSUE IN THE SAME LOCATION HOWEVER THAT WAS FOR 2003 - 2005 VEHICLES. *JS
VEHICLE PARKED IN PARKING LOT AT 9:30P.M. SHERIFF WOKE US UP 2:00 A.M. BANGING ON WINDOWS STATING SUV WAS ON FIRE. 3 OTHER VEHICLES WERE DAMAGED BECAUSE OF FIRE. I AM BLESSED MYSELF AND MY CHILDREN WERE NOT IN SUV AT THAT TIME. ALSO DAMAGED PARKING AREA. *TR
THE DOME LIGHT ON THE 2002 FORD ESCAPE 3.0L CAUSED BURNING ON THE SUNROOF SLIDING COVER WHEN THE COVER WAS OPENED. THIS HAS THE POTENTIAL TO STARTING A FIRE, ALTHOUGH NOW THEREWAS ONLY A SLOW BURN. *AK
WHILE VEHICLE WAS PARKED A FIRE STARTED UNDER THE HOOD. VEHICLE WAS TOTALED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
COMPLAINT REGARDING COUNTY OF TUOLUMNE CALIFORNIA SHERIFF'S DEPARTMENT FOUR NEW CROWN VICTORIAS.*MR (NAR) *CB
PROBLEMS WITH FUEL INJECTORS CAUSED VEHICLE FIRE.*MR THE CONSUMER STATED HE WAS SERVICING THE R.V WHEN ALL OF A SUDDEN THERE WAS A SOUND UNDER THE ENGINE COVER AND THE VEHICLE WAS ON FIRE. IT WAS DETERMINED THE FUEL INJECTORS WERE LEAKING. (CHATEAU MOTORHOME ON A FORD CHASSIS) *JB
FRONT END CRASH WITH 2002 FORD CROWN VIC ON INTERSTATE 95 IN BALTIMORE COUNTY MARYLAND. THE PASSENGER AIR BAG DEPLOYED BUT THE DRIVERS SIDE AIR BAG DID NOT. PRIOR TO THIS ACCIDENT THIS MORNING THERE HAD NOT BEEN ANY INDICATION THAT THE AIR BAG SYSTEM HAD ANY PROBLEMS. THE DAMAGE WAS THE RIGHT FRONT FENDER, BUMPER, AND HOOD. THE VEHICLE HAD TO BE TOWED. *JB
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.