2005 Volvo XC90
6 recalls and 223 owner complaints on record for this model year.
Check a specific vehicle
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VIN6 recalls and 223 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
The vehicle's braking functionality can be disabled while using 'B' mode (in plug-in hybrid cars) or One Pedal Drive (in pure electric cars), after coasting downhill. This can lead to a collision and increase the risk of accidents and injuries. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The rod between the brake pedal and the brake booster may not have been assembled correctly. The rod can become detached, leading the brake pedal to dysfunction, increasing the risk of accidents and injuries. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
TL* THE CONTACT OWNS A 2005 VOLVO XC90. THE CONTACT STATED THAT WATER LEAKED INTO THE VEHICLE THROUGH THE SUN ROOF. THE WATER CAUSED DAMAGED TO THE HEADLINER AND FLOORBOARD CARPET. THE FAILURE ALSO CAUSED THE SEATS TO MOVE INDEPENDENTLY AND A GROWTH OF MOLD AND MILDEW INSIDE THE VEHICLE. THE CONTACT ALSO STATED THAT THERE WERE SEVERAL WATER BUGS AND OTHER TYPES OF INSECTS INFESTING THE VEHICLE DUE TO THE WATER ACCUMULATION. THE CONTACT SUFFERED FROM MEDICAL DISTRESS AS A RESULT OF THE FAILURE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSIS BUT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DECLINED TO REPAIR THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO TWO INDEPENDENT MECHANICS BUT THEY WERE UNABLE TO DRAIN THE SEVERAL GALLONS OF WATER THAT COULD BE HEARD FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 122,000. THE CURRENT VEHICLE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.
WHEN CRANKING IT STALLS AND CUTS OFF AND AFTER DOING IT AROUND 10 TIMES IT FINALLY CRANKS THEN I HAVE TO HURRY TO PUT IN DRIVE TO GET THE MOTOR GOING IN ORDER TO KEEP HER CRUNK AND COUPLE WEEKS AGO BECAUSE THIS PROBLEM SHE STALLED OUT AND I HIT A HOLE IN THE ROAD AND BUSTED THE OIL PAN SO SHE HAS BEEN PARKED EVERY SINCE CAUSE I HAD MY DAUGHTER IN THE CAR AND THAT WASN'T A PRETTY SIGHT SINCE THE HIT MADE HER NERVOUS NOW CAN'T GET HER TO GET IN THE CAR SO I NEED MY CAR FIXED AND I SEE IT HAS SEVERAL RECALLS AND ALL AND IT WAS ON A COUNTY STREET ONCE I GOT IT CRUNK BACK UP IT SMOKED BADLY TILL I TURNED IT OFF AND IT TOOK FOUR HOURS FOR ME TO GET IT OUT THE ROAD
TL* - THE CONTACT OWNS A 2005 VOLVO X90. WHILE DRIVING 10 MPH SMOKE CAME FROM UNDER THE HOOD. THERE WERE NO WARNING INDICATORS. THE VEHICLE WAS PULLED OVER, AND THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE FAILURE MILEAGE WAS 23,000. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. A FIRE REPORT FILED, AND THE CONTACT HAS PICTURES. *AK
I WAS DRIVING MY 2005 VOLVO XC90 AWD A FROM MY HOME TO WORK(ABOUT 20 MILES) WHEN I WAS PARKING THE CAR ON A PARKING LOT, I NOTICED SMOKE COMING FROM UNDER THE HOOD. THE NEXT MOMENT I SAW A LITTLE FIRE COMING FROM UNDER THE HOOD. I STOPPED THE CAR AND GOT OUT. THE FIRE WAS GETTING BIGGER AND BIGGER. I IMMEDIATELY CALLED 911. BY THE TIME THE FIRE ENGINE ARRIVED THE CAR WAS IN FLAMES, AND THE FRONT WINDSHIELD CRACKED AND FELL INSIDE THE CAR. THE FRONT SEATS AND MY PERSONAL PROPERTY WERE BURNED. *JB
DRIVING IN PITCH BLACK NIGHT ON BACKROADS OF CHARLESTON, SC. LIGHTS WENT OUT AFTER LEFT HEADLIGHT FLICKERED FOR A FEW DAYS. LIGHTS WENT OUT AND CAR WENT OFF ROAD AS WE WERE IN A CURVE. REGAINED CONTROL AFTER SPINNING ON WET GRASS. I NEED THE HEADLIGHTS REPAIRED BY VOLVO AT THEIR EXPENSE AND REIMBURSEMENT FOR THE FAILED ENGINE I HAD TO REPLACE. *TR
I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and car hasn't ran since. Upon investigation I found the CEM was effected. When the car died I was in left hand lane and I had to make my way to right, the shoulder. Yes the problem was diagnosed by myself. However I did investigation and researched using all data at library. It has not been inspected by anyone else. There where no warning lamps or messages prior to the failure. It happened all of a sudden in the middle of traffic when I was getting off the highway.
I’ve had to change my fuel injection pump and catalytic convert twice on one year.
ADAS, AIR BAR Warning lights/urgent and High Gas fumes coming out from the rear seats when fully filled gas. We had called 800-458-1552 and guided us to plug in our VIN [XXX] on www.volvocars.com and nothing showed as far as recall and told us that these recalls expired and our 2005 Volvo are not eligible. 2005 Volvo XC90 that relates to NHTSA Campaign Number: 09V483000, Make: VOLVO Model: XC90 Model Year: 2005 Manufacturer: VOLVO CARS OF N.A. LLC. Mfr's Report Date: DEC 17, 2009 NHTSA CAMPAIGN ID Number: 09V483000 NHTSA Action Number: PE09039 Component: FUEL SYSTEM, GASOLINEELIVERY:FUEL PUMP Potential Number of Units Affected: 136100 Summary: VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE. Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552. My wife and I had purchased our Volvo XC90 in 2005, here in CA. Six months ago everytime we filled up the gas tank, we would smell a heavy fumes of gas as it was coming from the inside of the vehicle. We had called the Volvo 800 number above and guided us to plug in our VIN [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Water is leaking from the windshield into the driver and passenger side inside on the window obstructing my view while driving. Cannot drive the vehicle while it’s raining. Serious safety problem! Please recall and fix all Volvos with this problem.
I HAD FILLED AN EARLIER COMPLAINT AND THIS TO BE ADDED TO THE EARLIER FORM THAT I HAD FILLED NEEDS TO GO TO THE ENGINEERING DEPARTMENT. SEE PHOTO THE ELECTRICAL COMPLAINT FROM THE MAGNETIC ELECTRICAL BEINGS IN ME AND IN THIS PICTURE I BELIEVE IS ABOUT DESIGN OF THE FUSES IN VEHICLE AND WHAT THEY ARE TRYIN TO COMMUNICATE HERE I BELIEVE WOULD BE THE DISTANCE BETWEEN THE POSITIVE AND NEGATIVE CONNECTIONS LIKE WHAT IT IS DOING TO THEM AS IT GOES THROUGH THOSE TYPES OF FUSES. WHAT I BELIEVE TO BE WHAT HAPPENS TO THEM IN THOSE PLASTIC FUSES AND WOULD LIKE THEM THE FUSE TO BE DESIGNED FURTHER APART A LITTLE BIT BIGGER THAN A PENNY AND WITH THE CONNECTION STRAIGHT ACROSS AND NOT GOING UP AND DOWN AND BACK THROUGH IT SELF. THE MAGNETIC BEINGS WOULD LIKE TO SEE THE CONNECTIONS STRAIGHT ACROSS SO THAT THEY DON'T INTERFERE WITH EACH OTHER WHILE TRAVELING THROUGH THE SUBSTRAIGHT. NOT SURE BUT YOU WERE THIS TYPE OF BEING YOU WOULD TRY AND COMMUNICATED THESE THINGS AND DESIGN WELL JUST LOOK AND IF YOU WOULD LIKE THEY LIKE THE OLDER GLASS FUSE WITH THE STAINLESS STEEL DESIGN. IF YOU COULD THEY ARE ASKING THAT YOU THE NTSB GO BACK REDESIGN A FUSE THAT DON'T GO BACK INTO ITSELF THEY LIKE STRAIGHT ACROSS THE CONNECTIONS TO GIVE THEM BETTER FLOW. REMINDER THIS GOES TO THE EARLIER FORM THAT I WROTE TO YOU IT AN ADDITION INFORMATION CAUSE THEY ARE IMPORTANT PART OF THIS WORLD I AM REFERRING TO THE MAGNETIC BEINGS IN ELECTRICITY IN EVERY VEHICLE MADE AND NEED TO BE TAKEN INTO MORE CONSIDERATION ESPECIALLY WHEN MAKING SYSTEMS THAT HEAVILY RELY ON THE ENTITIES. THEY THE BEINGS ARE ASKING THIS OF YOU THENTSB TO TAKE THEM MORE INTO CONSIDERATION AS WE US THEM RELY ON THEM THE INVISIBLE MAGNETIC ELECTRICAL BEINGS MORE AND TO DEVELOP FRIENDLIER AND HEAVIER SYSTEM FOR THEM BECAUSE THE DESIGN NOW IS MAKING THEM SICK AND THEY ARE I AM ASKING FOR THE ENTITIES THAT YOU MAKE HEALTHYELECTRICITY
BOUGHT CAR AND BEEN HAVING PROBLEMS EVERY SINCE I HAVE HAD PROBLEMS I KEEP FUEL INJECTION IN IT SO I CAN MOVE THE CAR TO POINT A AND B
THE KNOWN VOLVO BALANCE SHAFT FAILURE IN THE 05 XC90 V8 B8444S ENGINES SN UP TO 6833.VOLVO HAS KNOWN THE V8 ENGINE ON THE 2005 XC90 IS FAULTY SINCE 2005.SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION & HUMIDITY.MINE HAS NOT FAILED YET.I WILL BE LUCKY IF IT FAILS WHILE AT IDLE.BERGERON VOLVO IN METAIRIE, LA, SOLD ME A TICKING TIME BOMB TO DRIVE MY 4 YEAR OLD SON AROUND IN.THERE WAS NO DISCLOSURE OF THE KNOWN CB SHAFT BEARING FAILURE!I WOULD NOT HAVE PURCHASED THIS FOR ME & MY LITTLE BOY!MY ENTIRE ENGINE WILL EVENTUALLY SEIZE UP & MY OTHERWISE BEAUTIFUL CLEAN CAR WILL BE A LARGE & USELESS PAPERWEIGHT.IF THIS HAPPENS WHILE THE CAR IS MOVING AT SPEED,IT COULD CAUSE A HORRIBLE ACCIDENT!UNLESS VOLVO ACTIVELY (AND, I AM ONE OF THEM #1868) FINDS THE REMAINING AFFECTED ENGINES IN SERVICE & FIXES THIS PROBLEM, IT REMIANS A RISK REGARDLESS OF THE MILEAGE.MY CAR CURRENTLY HAS ONLY 72K MILES ON IT! I AM TRYING TO PREVENT THIS FORM HAPPENING, AND NEEDS TO BE PAID FOR BY VOLVO.THIS IS SOMETHING THAT IS IMPOSSIBLE FOR ME TO PREVENTATIVELY MAINTAIN! APPROPRIATELY,THEY SHOULD ALSO REIMBURSE ANYONE WHO WAS AFFECTED BY THIS PROBLEM SINCE THEY LEARNED ABOUT IT BACK IN 2005. THE BERGERONVOLVOCARS.COM SITE STATES MR. DENIS BERGERON HAS AN OPEN DOOR POLICY, WHEREBY CUSTOMERS CAN CONTACT HIM DIRECTLY,I EMAILED MR. BERGERON MY CONCERN LAST WEEK AND HAVE YET TO HEAR BACK FROM HIM. I WOULD LIKE A CALL BACK & SIT DOWN WITH MR. BERGERON TO HAVE THIS ENGINE DEFECT FIXED BEFORE I AM IN A HORRIBLE ACCIDENT OR LEFT WITHOUT A CAR.SOME WEBSITES FOR REFERENCE: HTTPS://WORKSHOP-MANUALS.COM/VOLVO/XC90_AWD/V8-4.4L_VIN_85_B8444S/ENGINE_COOLING_AND_EXHAUST/ENGINE/TIMING_COMPONENTS/BALANCE_SHAFT_BEARING/COMPONENT_INFORMATION/SERVICE_AND_REPAIR/ ; HTTPS://BLOG.FCPEURO.COM/THE-DARK-SIDE-OF-VOLVOS-EXCELLENT-V8 ; HTTPS://WWW.MATTHEWSVOLVOSITE.COM/FORUMS/VIEWTOPIC.PHP?F=10&T=87848
TL* THE CONTACT OWNS A 2005 VOLVO XC90. EVER SINCE THE VEHICLE WAS PURCHASED IN NOVEMBER OF 2018, THERE HAD BEEN SEVERAL ELECTRICAL FAILURES. THE HEADLIGHTS, POWER DOOR LOCKS, AND POWER REARVIEW MIRROR FAILED TO OPERATE. ALSO, THE TRANSMISSION CAUSED THE VEHICLE TO JERK AND STALL WHILE DRIVING. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN VOLVO DEALER, BUT THEY REFUSED TO PROVIDE DIAGNOSTIC TESTING AND STATED THAT THERE WAS NO RECALL OR WARRANTY COVERAGE ON THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 14,042.
GASTANK WAS LEAKING WHEN I WAS FILLING UP IN FULL TANK NOT VERY MUCH BUT I SMELL WHENEVER I WAS PARKING
PASSENGER DOOR INTERMITTENTLY SWINGS OPEN WHILE DRIVING, EVEN WHILE LOCKED. FAULTY LATCH.
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.
Remedy: DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
The second row seat belt buckle may have not been tightened to the correct torque. As a result, the seat belt may not provide sufficient protection for the second row passengers in the event of an accident, increasing the risk of injury. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The nitrogen oxide (NOx) emissions are above the regulatory limits. Excessive NOx emissions pose a risk to the environment. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
A software error in the brake control module can lead to a loss of braking power, creating a risk of an accident. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Matched on brand and model name — Safety Gate publishes no VIN. Check the production dates, and quote the recall code to a dealer.