2016 Ford F-150
14 recalls and 59 owner complaints on record for this model year.
Check a specific vehicle
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VIN14 recalls and 59 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Tenneco Automotive (DRiV) is recalling certain MOOG K500359 ball joints, for aftermarket installation on 2015-2018 Ford F-150 trucks. The ball joint may have a misaligned dust boot and may be missing alignment hole and installation warning tag, which may lead to improper alignment of the ball joint.
Remedy: DRiV will notify owners, and dealers will inspect, and if necessary replace the ball joint, free of charge. Owner letters were mailed May 5, 2021. Owners may contact Tenneco Automotive customer service at 1-877-489-6659.
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.
Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.
Ford Motor Company (Ford) is recalling certain model year 2016 F-150 trucks manufactured April 27, 2015, to November 22, 2015, and equipped with Multi-Contour Seats (MCS). The front passenger seat Occupant Classification System (OCS) that calibrates the air bag deployment level may incorrectly classify an adult as a child when the seat massage feature is activated.
Remedy: Ford will notify owners, and dealers will update the Occupant Classification System Module (OCSM) with new software, free of charge. The recall began on March 11, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S05.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
The rear axle wiring can touch the rear axle housing and rub against it over time, damaging the electric parking brake cables. This can cause the parking brake to be applied unintentionally while driving, which can result in loss of vehicle control, increasing the risk of an accident. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Matched on brand and model name — Safety Gate publishes no VIN. Check the production dates, and quote the recall code to a dealer.
Was involved in a head on collision involving 2 cars; one which was hit in the front driver wheel panel and the other was directly head on and the air bags did not deploy. Resulting in major seatbelt bruising and knee injury.
This vehicle 2016 ford F150 is known to have shorting issues. From literally all wiring harnesses. I had a small fire in my truck due to this issue, caused melting of the ribbon cable in my seat heater control module, which is a known issue from Ford. I have shorting in my turn signal switch (no wipers). Is that safe? I am a research scientist and engineer, I can tell you now it is not safe. If i need to prove it, I can do so with ease and write the necessary literature. If I cant use my AC sometimes, the windows fog, then i cant use the wipers to unfog them, how is this not a visibility issue? Not to mention all the shorts. I have a 40 gallon fuel tank, if any shorts get near it, is that going to be a fun experience for me? Please give Ford a penalty, the average owner of this truck pays thousands a year in repairs. I paid $17,800.00 in 2025 to repair this piece of shit. And it still has major issues. This is something ford needs to address, i want my wiring to be replaced, i bought a new engine, what if i cant use it especailly with the 3 year warranty bc the wiring consistently shorts and fails. unacceptable for a truck that's sticker price is $80k. This is a major problem, I will file claims until im afforded a response
The contact owns a 2016 Ford F-150. The contact stated that while driving at approximately 30 MPH, the vehicle hesitated to maintain acceleration while the accelerator pedal was depressed, which caused the vehicle to jerk forward into the rear bumper of another vehicle in traffic. The front bumper struck the rear bumper of the other vehicle. A warning message reading "Cannot Exceed 80 MPH" and an additional unknown warning message were displayed. The air bags did not deploy. No injuries were reported. A police report was not filed. The vehicle was taken to an independent mechanic, where the front bumper was replaced at the contact's expense. The vehicle was later repaired under NHTSA Campaign Number: 26V237000 (Powertrain); however, the repair failed to prevent the failure from recurring. The vehicle was taken back to the same dealer, where it was determined that the vehicle needed further diagnostic testing for a possible transmission repair. The vehicle was not repaired due to cost and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 88,000.
Back up camera malfunctioned, not showing there was a smaller car behind me in my own driveway. Backing up into my driveway at night, it did not pick up or show the smaller car which I back up into, causing $2890 in damages which I had to pay for.
The vehicle experienced a sudden and unexpected loss of power steering assistance while being driven on a highway. The failure made the vehicle extremely difficult to steer and nearly caused an accident, creating a serious safety hazard. After pulling over to get off the highway, it was observed at lower speeds, the vehicle did not have its full range of steering also creating a safety hazard. The problem was confirmed by the dealer, who determined that the power steering gear system had failed. The dealer replaced and repaired the entire power steering system. No warning lights or other alerts appeared before the failure. The sudden loss of steering assistance occurred without warning while the vehicle was in motion, significantly increasing the risk of a crash.
The contact owns a 2016 Ford F-150. The contact stated that while attempting to depress the horn pad on the steering wheel, the horn failed to provide an audible sound as intended. The air bag warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed and determined that the clockspring needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 39,825.
The contact owns a 2016 Ford F-150. The contact stated that while driving 70 MPH, the transmission unexpectedly downshifted to 3rd gear. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train); however, the dealer and manufacturer stated that the VIN was not included in the recall, and the fault code listed in the recall was not retrieved from the vehicle. The contact stated that after the vehicle skidded on the roadway after the unexpected downshift, there was an orange WRENCH light illuminated on the instrument panel. The manufacturer was notified of the failure. The vehicle was not repaired.
In April of this year my 2016 F150 began having issues related to the automatic transmission. Symptoms included unexpected and irregular downshifting from 6th gear into 4th gear while traveling on the highway, random and irregular shifting from gear to gear, and not gearing down below 3rd gear when coming to a complete stop. While these symptoms were happening the truck displayed the MIL and powertrain warning lamp. These issues put myself and others at risk because having the vehicle unexpectedly downshift while traveling at a high speed causes the vehicle to become difficult to control, increasing the risk of a crash. It is also difficult for the vehicle to increase speed in a timely and safe manner when it is starting out in 3rd gear. In May I received a recall notice from Ford, eventually in July having the dealer closest to me perform a PCM software upgrade. While waiting for Ford to make this software upgrade available I received a notice from Ford referencing Customer Satisfaction Program 26N04. This notice states that if my vehicle set a MIL and/or powertrain warning light (which my vehicle did both) I may need to get the transmission molded leadframe replaced as part of this recall program. When I picked up my vehicle from servicing dealership I was informed my vehicle "did not have the appropriate code" to warrant this repair. However, the software upgrade performed has done nothing to fix the problem I am experiencing. My vehicle still downshifts randomly and unexpectedly while displaying a powertrain warning light, and making my vehicle unsafe for highway travel.
The contact owns a 2016 Ford F-150. The contact received an unknown recall notification. The dealer was contacted by phone and scheduled an appointment for a technician to pick up the vehicle. The technician drove the vehicle to the dealer. The unknown recall repair was completed. The contact received a phone call from the dealer and was informed that while the technician was in route and driving the vehicle back to the residence, the transmission independently shifted from fourth gear to first gear. The technician drove the vehicle to the dealer. The vehicle was with the dealer for two weeks. The contact received a phone call and was informed that no warning lights were displayed, and the failure could not be duplicated. The contact was informed to pick up the vehicle. The dealer informed the contact that there was no fix available. The contact was informed that the dealer would not be offering any additional repairs. The contact stated that the vehicle had no issues prior to the unknown recall repair. The failure mileage was approximately 128,000.
The contact owns a 2016 Ford F-150. The contact stated that vehicle was taken to the local dealer for a recall repair associated with the PCM reprogramming. Upon retrieval, the vehicle went into LIMP Mode while driving. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted to a lower gear, and the vehicle lost motive power. The dealer was contacted and provided the contact with an estimate for a diagnostic test. The contact spoke with a supervisor, but no additional assistance was provided.
The contact owns a 2016 Ford F-150. The contact stated that the vehicle was repaired under an undisclosed recall; however, the recall repair failed to prevent a failure. The contact stated that while driving at an undisclosed speed, the vehicle hesitated while upshifting or downshifting between 4th and 6th gear. The same local dealer was contacted and advised the contact that the 4th and 6th clutches were burned. The manufacturer was made aware of the failure. The failure mileage was approximately 249,000.
I would like to file complaint against Ford for their latest recall (26N041) and how they are not doing replacing the defective Lead Frame in customers vehicles. It's a big scam and a waste of time. I brought my 2016 Ford F-150 in for Ford’s latest recall (26N04) affecting 2015–2017 models due to the transmission leadframe issue. I explained that I’ve been dealing with an intermittent problem for the past seven months: while driving, the gear indicator lights on the dash begin to flicker, and when that happens, the transmission shifts extremely hard and slams into the next gear. Ford kept my truck for a week and told me they were unable to duplicate the issue. They stated that multiple technicians drove the vehicle and none of them observed any problems. When I arrived to pick it up, I was handed a bill for more than $250 for a diagnostic fee. Within four miles of leaving the dealership, the gear indicator lights began flickering again. It’s difficult to accept that several technicians drove the truck over multiple days and never encountered the issue I experienced almost immediately. The entire process felt like a waste of time and money, and I’m left without any resolution to a problem that clearly still exists. They are not honoring the recall, they are trying to charge customers for the repair.
Truck downshifts into low gear, yellow wrench and engine light come on and the truck goes into limp mode, no warnings or anything. These symptoms first started about 5 months ago and I have stopped driving the truck for that time. I took it to the dealer after looking it up and seeing there was a recall 26S28 for the molded leadframe. At the dealer they told me they couldn't perform the service because my truck was showing codes: P061A-00, P0720-00, and P0722-00 and they needed: P0705, P0706, P0707, P1702 to perform the recall service. My codes also point to the molded leadframe but the speed sensors instead of the range sensors.
XXX, my Ford F-150 began experiencing serious and unpredictable transmission shifting problems. The truck would downshift unexpectedly while traveling at various speeds. At times, it would not downshift properly when coming to a complete stop, and it would sometimes shift back up into third gear from a complete stop at a stoplight.On one occasion, while traveling approximately 65 mph, the truck unexpectedly downshifted. The sudden change in the vehicle's behavior was extremely unsettling and made me concerned about maintaining control. What made the situation even more frightening was that I had no center lane or safe area to pull over without potentially becoming a hazard to the traffic around me. I had nowhere to simply get out of the way and figure out what was happening. That is an extremely unsettling feeling when you are traveling at highway speeds. Another incident was even more frightening. While traveling approximately 55 mph on the highway, the truck unexpectedly downshifted while a logging truck was traveling directly behind me. Fortunately, I was able to maintain control of the vehicle and safely pull onto the shoulder. I contacted my local Ford dealer and was told that its a Software repair, was not yet available and that I would need to wait for Ford's software fix. Extremely concerned about continuing to drive a vehicle that was behaving this way, I contacted Ford directly and asked Is it safe to continue driving the vehicle? Response -Ford was not advising owners to discontinue operation of the vehicle. Took place on XXX, at approximately 8:11 a.m. with Ford representative [XXX]. On XXX, I bring the truck to the Ford dealership for the software update. I received the vehicle back the same day, expected the problem had finally been corrected. Like I never had the truck "software" fix. Back to dealership - they redid the software fix, not fixed. No codes, and still no fix for the transmission shifting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On August 21, 2026, my 2016 Ford F-150 was serviced at Five Star Ford to perform safety recall 26S28 (Powertrain Control Module software update). Immediately following this software flash, the transmission's shifting logic became severely corrupted and unsafe to drive. The vehicle currently acts as if it has completely lost 2nd gear, experiences a severe lag when shifting up into 6th gear, and repeatedly fails to lock itself into 3rd, 4th, or 5th gears. The dealership is currently using a temporary lack of hard Diagnostic Trouble Codes (DTCs) to deny coverage for an internal physical lead frame component replacement under the 26S28 extended warranty guidelines, claiming instead that a complete, out-of-pocket transmission replacement assembly is required. The safety update has directly induced a severe driving hazard, leaving the vehicle unable to properly find or maintain standard highway gears.
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.