2010 Volvo XC60
7 recalls and 56 owner complaints on record for this model year.
Check a specific vehicle
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VIN7 recalls and 56 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Remedy: DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC60 VEHICLES. THE CURTAIN AIR BAGS MAY HAVE BEEN MIS-ASSEMBLED DURING THE MANUFACTURING PROCESS. THIS MAY CAUSE AN AIR BAG TO NOT DEPLOY OR NOT DEPLOY AS INTENDED.
Remedy: DEALERS WILL INSPECT THE LEFT AND RIGHT CURTAIN AIR BAG ASSEMBLY AND ADJUST IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 9, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE FUEL LINE RAIL COVER THAT PROTECTS THE FUEL LINES UNDER THE VEHICLE MAY NOT BE PROPERLY ATTACHED EXPOSING THE FUEL LINES TO DAMAGE.
Remedy: DEALERS WILL INSPECT THE FUEL LINE RAIL COVER FOR PROPER ATTACHMENT AND REATTACH IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 28, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES BUILT WITHOUT THE PANORAMIC ROOF AND DELIVERED TO PUERTO RICO FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."
Remedy: THESE FOUR VEHICLES ARE IN THE POSSESSION OF DEALERS IN PUERTO RICO AND DEALERS WILL REPLACE THE HEADLINER IN THE VEHICLE PRIOR TO SALE.
VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE DRIVER'S SEAT SIDE COVER PANEL (SEAT CONTROL PANEL) IN CERTAIN DRIVER'S SIDE IMPACTS MAY RELEASE THE ATTACHMENT OF THE SEATBELT TO THE SEAT FRAME.
Remedy: DEALERS WILL MODIFY THE INSIDE OF THE DRIVER'S SEAT SIDE COVER PANEL FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
The vehicle's braking functionality can be disabled while using 'B' mode (in plug-in hybrid cars) or One Pedal Drive (in pure electric cars), after coasting downhill. This can lead to a collision and increase the risk of accidents and injuries. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Some problems with the high-voltage battery can cause an overheating of the battery cells when the battery is fully charged. This can lead the vehicle catch fire. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The rod between the brake pedal and the brake booster may not have been assembled correctly. The rod can become detached, leading the brake pedal to dysfunction, increasing the risk of accidents and injuries. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The nitrogen oxide (NOx) emissions are above the regulatory limits. Excessive NOx emissions pose a risk to the environment. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
A software error in the brake control module can lead to a loss of braking power, creating a risk of an accident. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Matched on brand and model name — Safety Gate publishes no VIN. Check the production dates, and quote the recall code to a dealer.
WHILE I WAS DRIVING THE CAR AROUND A CORNER AFTER STOPPING, I HAD A FRONTAL COLLISION WITH ANOTHER CAR. MY CRASH AVOIDANCE SYSTEM DID NOT ACTIVATE. I WOULD LIKE THE BLACK BOX OF MY VEHICLE TO BE CHECKED. VOLVO NORTH AMERICA WAS NOT HELPFUL WHEN I CALLED THEM.
MY CUSTOMER WAS HEADED NORTHBOUND ON HWY 63, HAD JUST PASSED OVER I-70 WHEN THE CUSTOMER HEARD A POOF AND SMOKE STARTED BELLOWING FROM THE HOOD AND THE TAILPIPE. THEY PULLED OVER ON THE SIDE OF THE ROAD IMMEDIATELY, BUT BY THEN SMOKE WAS COMING OUT OF THE VENTS AS WELL. THEY GOT OUT OF THE CAR, AND CALLED 911 BECAUSE OF SMOKE STARTED TO THICKEN. ABOUT ONE MINUTE LATER, FLAMES STARTED COMING OUT FROM UNDERNEATH THE RIGHT (PASS) SIDE OF THE CAR AND WITHIN 25-30 SECONDS, FLAMES WERE COMING FROM UP UNDER THE HOOD AS WELL. THE FIRE DEPARTMENT GOT THERE AND PUT OUT THE FIRE. THE VEHICLE WAS TOWED BACK TO THE DEALERSHIP FROM THERE. THE CAR WAS IN PERFECT CONDITION. IT PASSED INSPECTION AT THE HONDA DEALERSHIP. WE DON'T KNOW WHAT HAPPENED OR WHAT WENT WRONG. WE DID SOME RESEARCH AND THERE WAS A RECALL NUMBER 09V477000; FUEL SYSTEM. THIS RECALL WAS SUPPOSEDLY FIXED BY VOLVO. WE CONTACTED VOLVO AND THEY SAID THAT THERE IS NOTHING THAT THEY COULD DO. HOWEVER, IN CARFAX THERE IS NO RECORD OF THE RECALL OR THAT THE RECALL WAS FIXED. *TR
While slowing down and just about to make a turn into a private residence off of a highway, multiple indicator lights illuminated and audio warning "dinging" occurred for approximately 3 seconds. As I had already been slowly applying the brakes and starting to slightly turn the wheel towards the driveway when those warnings briefly came up, the moment the lights and sounds stopped, vehicle then maintained speed (while still on the brakes) and locked steering position it was at simultaneously. Having no control at that point, it continued until crashing into a wooden fence. Once at a complete stop, cabin lights and "dinging" activated as it acknowledged the impact. And although it was only going about 15 mph, seemingly to only have damage to the front passenger side bumper/headlight area, it would not shift into any gear or turn off. Not to mention that the front passenger side airbag(s), or any of them, deploy- seriously raised even more concerns as the main reason I purchased a Volvo was for their well known status of safety standards. Had this obvious electrical malfunction happened moments before at higher speed/steering straight ahead, it would've resulted in very serious injuries to myself and others while it speed through 2 intersections at a highway ramp just down the hill. Was towed to a local collision repair & auto body shop until Progressive Insurance took it to their damage assessor where it was declared a total loss. I've owned it for almost 3 years and always had weird inconsistent electrical "quirks"- nothing ever of serious concern though. Has spent a total of 4-5 months in the past 3 years at different Volvo dealerships and mechanics but no one could ever explain why different warnings would be displayed randomly for days-weeks, off/on for no apparent diagnostic reason, 12V power socket was the same way... Please investigate the electrical components that directly affect the operational use and control! Extremely common & dangerous issue with these!
2010 VOLVO XC60 SURGED ON THREE OCCASIONS WHILE STOPPED AT A RED LIGHT. *KB THE CONSUMER STATED THE FIRST TIME THE INCIDENT HAPPENED, THE VEHICLE BEGAN TO MOVE FORWARD AND THE TACHOMETER READING WAS 2500 RPM. THE LIGHT HAPPENED TO TURN GREEN BEFORE THE VEHICLE WENT ANY FURTHER. THE SECOND TIME, THE SAME THING HAPPENED. THE THIRD TIME, WHILE AT A RED LIGHT, THE VEHICLE SURGED AND THE TACHOMETER READING WAS 4500 RPM. THE CONSUMER PLACED THE GEAR IN NEUTRAL AND THE TACHOMETER INCREASED TO 5500 RPM. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE UNABLE TO FIND A PROBLEM. SINCE THE VEHICLE WAS A LEASE, THE DEALER GAVE THE CONSUMER ANOTHER VEHICLE, SAME MAKE AND MODEL. HOWEVER, THE REPLACEMENT VEHICLE ALSO SURGED WHILE STOPPED AT A RED LIGHT AND SHOT FORWARD INTO THE REAR OF ANOTHER VEHICLE. *JB
After it rains, i've noticed water collecting in both the passenger and driver side footbeds. It started off nominally and I was easily able to use a cloth. I thought it might have been human error, that I left the window cracked open a bit. The most recent incident (this past weekend 5/4/24) there was a significant puddle on the driver's side. After further research, I discovered the culprit is likely an unbonded windshield, and that this is a KNOWN issue for Volvos, but especially for (2010) xc60s. Having an unbonded windshield seems like a significant hazard risk as the structural integrity of the entire windshield is compromised, as well as risk of electrical components getting wet as the water leaks through the car (and the ripple effects of that).
Front windshield completely separated from vehicle driver side top If side window open it flaps open. Very dangerous at freeway speeds. Known issue of faulty primer on window glass for XC60 vehicles.
Front windshield is not sealed properly. Leaks water at top of windshield and onto the steering wheel. This is not a problem with the sunroof.
Airbag fault lamp illuminated. Trouble code U0433 stored in body module (CEM). The problem described is with the closing velocity module, a component of the collision mitigation system. There is a TSB available from Volvo for this code, reference number US25146.1.1. It states a software update must be performed to resolve the error. My complaint is that the airbag system is affected and shows an airbag fault lamp, which prevents passing vehicle inspection in my state. The collision avoidance system can be turned off by the driver. As such, there is no cause for disabling or otherwise negatively affecting the airbag system in the event of a fault. A remedy is not provided free of charge from Volvo, and it should be so as this issue prevents legal operation of the car despite the affected system (collision mitigation) being designed to be turned off by the user.
Seal around the top of the windshield has failed and worn out. You are now able to press on the windshield and have it unseat from the car frame
Windshield seal was defective causing water leakage into the dash.
I attempted to use the temporary spare tire that came with the car, and 1) the lug wrench provided with the car rounded out when trying to remove the lug bolts, 2) the lug bolts were too long and bottom out in the hub before they tighten down the thin steel spare rim to the car. In short, the spare tire is does not work with the lug bolts that come with the car. This poses a risk as owners will reasonable think they have a means to mitigate a flat tire and be caught stranded as even a well maintained, factor-designed spare tire kit is useless.
Windshield seal developed leak. Water go into hvac shorting out system. No defrost, sever visibility and safety issue. Have seen numerous other volvo owners with similar windshield gasket seal leaks. Car is useless as visibility issue persists
The contact owns a 2010 Volvo XC60. The contact stated that while driving at an undisclosed speed, the charging system failure warning message was displayed, and the battery warning light was illuminated. The vehicle was taken to an independent mechanic. The mechanic replaced the battery and alternator; however, the failure recurred. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The contact related the failure to Volvo's Technical Service Bulletin: TJ 27910 (Anti-Tamper Device, Communication Lost). The failure mileage was approximately 148,000.
WATER COLLECTS IN THE DRIVER SIDE FOOTWELL AFTER EVERY RAIN. WHILE DRIVING DURING RAINS, WATER LEAKS FROM (1) DRIVER SIDE TOP LEFT CORNER (2) "A" PILLAR AND (3) LOWER LEFT CORNER OF DASHBOARD AT EMERGENCY BRAKE RELEASE. TOOK XC60 TO LOCAL VOLVO DEALER WHERE THE WINDSHIELD WAS PULLED AND RESET. FRONT FLOOR CARPETS WERE PULLED, FAN-DRIED AND REINSTALLED. VOLVO WAIVED THE CHARGE FOR WINDSHIELD REINSTALL, BUT WOULD NOT WAIVE CHARGES FOR CARPET SERVICES. THIS VEHICLE HAS EXPERIENCED THIS PROBLEM EARLIER, REQUIRING A WINDSHIELD REPLACEMENT.
THE WINDSHIELD LEAKS WHEN IT RAINS. IT OBSTRUCTS MY VISION WHILE THE RAIN WATER RAN DOWN THE INSIDE OF THE GLASS. THIS IS A SAFETY ISSUE WHILE DRIVING.
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.