2011 BMW 528i
4 recalls and 198 owner complaints on record for this model year.
Check a specific vehicle
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VIN4 recalls and 198 owner complaints on record for this model year.
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINAlmost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
Remedy: BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2011 BMW 528i, 528xi, 535i, 535xi, 550i and 550xi vehicles manufactured March 1, 2010, through August 31, 2011. The affected vehicles may have received a replacement Sensor Cluster Unit (SCU) during a service visit. These SCUs have an acceleration sensor that may have been incorrectly programmed and, as a result, the SCU may not accurately determine if activation and deployment of the air bags, safety belt pre-tensioners and head restraints is necessary in the event of a crash.
Remedy: BMW will notify owners, and dealers will replace the SCU, free of charge. The recall began on December 16, 2016. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.
Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
Remedy: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
THERE ARE 3 MAJOR ISSUES. 1. VEHICLE TENDS TO VEER TO THE RIGHT. FEELING IS QUITE LIKE A VEHICLE THAT HASN'T BEEN ALIGNED FOR A WHILE. 2. THE MOST DANGEROUS. UPON ACCELERATION AND/OR AT LOW SPEED, THE VEHICLE RANDOMLY JERKS FORWARD WITHOUT ANY NOTICE- MAKING IT TOO LATE FOR THE DRIVER TO SLAM THE BRAKES. IF YOUR VEHICLE IS STANDING THREE FEET BEHIND ANOTHER VEHICLE IN STOP AND GO TRAFFIC, YOU CAN EASILY CRASH AND REAR END INTO THE CAR IN FRONT OF YOU. AND OF COURSE, YOU WILL BE SUED FOR NOT KEEPING YOUR DISTANCE. THIS CAN EASILY CAUSE SOME SERIOUS INJURIES. 3. VEHICLE WOBBLES AS IF THE TIRES WERE NOT BALANCED. THERE ARE CLEARLY UNKNOWN DEFECTS THAT CAN NOT BE LOCATED. TOOK IT TO THE LOCAL BMW DEALER, THEY KEEP ASCRIBING IT TO "NORMAL" CHARACTERISTICS AND THEY KEEP INFORMING ME THAT BMWS ARE BUILT THAT WAY, THEY ARE NOW SPORTIER. HOWEVER, TO ANY NEW OWNER, IT IS NOW DEADLIER. THE LOCAL BMW DEALER ALSO STATE UNLESS THEY VEHICLE DOESN'T INFORM THEM ABOUT THE ISSUE THEY CAN'T DO ANYTHING. ITS MORE LIKE, UNTIL SOMEONE DOESN'T SUE THEM IS WHEN THEY WILL DO SOMETHING ABOUT IT. BMW SERIOUSLY NEEDS TO LOOK INTO THIS ISSUE IMMEDIATELY BEFORE A CLASS ACTION LAWSUIT BEGINS AGAINST THEM.
The contact owns a 2011 BMW 528I. The contact stated while driving approximately 35 MPH, the vehicle made an abnormal sound and stalled. The check engine warning light and brake warning light repeatedly illuminated on and off. The vehicle was difficult to control, causing the contact to drive over a pothole, causing the rear window glass to shatter. The contact's two children were in the rear seats, and one was cut in the back of the neck with the shattered glass. No medical attention was sought. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) prior to the failure; however, the part to do the recall repair was unavailable. The contact believed that the failure was caused by the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was drivable and was driven back to the residence. The vehicle was not repaired. A dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was 170,000. VIN tool confirms parts not available.
WE BOUGHT A 2011 BMW 528I WHILE IT WAS UNDER WARRANTY. WE STARTED TO HAVE ISSUES RIGHT AFTER THAT. PULLING RIGHT, ELECTRONICS FREEZING, CAN NOT UNLOCK THE DOORS WITH KEY FOB, CAN NOT GET OUT FROM CAR BECAUSE DOOR HANDLES DO NOT WORK TIME TO TIME AND OUR 2 YEAR OLD SON GOT LOCKED INSIDE(CAR LOCKED BY IT SELF) AND WE HAD TO BREAK THE WINDOW WHICH TOOK ALMOST 30 MINUTES. BMW SAID THEY COULD NOT FIND ANY PROBLEM AND WENT EVEN FURTHER SOME OF THE ISSUES ARE FEATURES OF THE CAR. OUR KIDS GETTING LOCKED IN THE CAR IS A SERIOUS ISSUE, CAN NOT GETTING FROM THE CAR IS ANOTHER SERIOUS ISSUE. WHAT IF CAR CATCHES A FIRE IN AN ACCIDENT AND WE GET STUCK IN THE CAR. PLEASE TAKE A LOOK AT IT. I DO HAVE VIDEO RECORDINGS IN MULTIPLIABLE OCCASIONS. EVEN BMW SERVICE TOOK THE CAR FOR THE SAME ISSUES AND CONFIRM IT WAS AN ISSUE. BUT COULD NOT PROVIDE ANY SOLUTION. IF SOMETHING HAPPENS TO SOMEONE BECAUSE OF THE ISSUES, IT WILL BE ON YOU GUYS IF YOU DO NOT TAKE ACTION IN THE ISSUE.
PURCHASED A BRAND NEW 528I BMW AND WITHIN MONTHS I HAD A COOLANT SIGNAL INDICATING LOW COOLANT. SUBSEQUENTLY, THE COOLANT SIGNAL CAME ON EVERY SIX WEEKS, DESPITE HAVING IT TOPPED OFF AT DEALERSHIP. CAR HAD INADEQUATE POWER AND FELT LIKE IT DRAGGED. BMW SERVICE CENTER REPEATEDLY FAILED TO IDENTIFY A PROBLEM. EVENTUALLY, THE SIGNAL CAME ON AND AN INTOLERABLE FUEL ODOR EMERGED UPON TURNING ON THE CAR. FUEL AND CHEMICAL ODORS REMAIN. I HAVE READ OF OTHER SIMILAR COMPLAINTS ONLINE AND BELIEVE THERE IS A MANUFACTURING DEFECT THAT MAKES THE CAR UNSAFE. THE EXPOSURE TO CARCINOGENIC COOLANT FUMES AND THE GAS FUMES ARE DANGEROUS. COOLANT MAY BE LEAKING INTO THE ENGINE. OTHER MECHANICAL ISSUES MAY BE CAUSING THE DRAG AND CONTINUED LOSS OF POWER. IN ONE INSTANCE I LEFT THE VEHICLE AT THE BMW SERVICE CENTER WITH A FULL TANK AND WHEN IT WAS RETURNED TO ME, THE FUEL LEVEL HAD DROPPED SIGNIFICANTLY DESPITE HAVING BEEN DRIVEN A VERY SMALL AMOUNT OF MILES BY THE SERVICE PEOPLE. I AM VERY CONCERNED THAT THESE PROBLEMS POSE A SAFETY HAZARD TO NOT ONLY MYSELF, BUT THE GENERAL PUBLIC AND OTHER BMW OWNERS WHO MAY BE UNAWARE OF THESE ISSUES. I FEEL THE CAR IS COMPROMISED BY THE MANUFACTURING DEFECTS AND THAT EFFORTS TO REPAIR THE PROBLEMS CONTINUE TO EXIST. I FEEL THE CAR IS UNSAFE AND POSES A SAFETY AND HEALTH HAZARD AND THAT BMW IS UNWILLING TO INVESTIGATE HOW PERVASIVE THE PROBLEM MAY BE. I WANT AN INVESTIGATION AND FEEL THE VEHICLE IS UNSAFE TO DRIVE. THIS IS NOT "THE ULTIMATE DRIVING MACHINE." PLEASE INVESTIGATE THESE PROBLEMS AND HELP PREVENT OTHERS FROM BEING UNNECESSARILY SUBJECTED TO TOXIC FUMES AND CHEMICALS WHICH MAY COMPROMISE THE PUBLIC'S HEALTH AND THE SAFETY OF PEOPLE ON THE ROAD.
TL* THE CONTACT OWNS A 2011 BMW 528I. THE CONTACT STATED THAT THE VEHICLE EMITTED AN ABNORMAL BURNING ODOR WHILE TRAVELING VARIOUS SPEEDS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. GLOBAL IMPORTS BMW (500 INTERSTATE N PKWY, ATLANTA, GA) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
WHILE DRIVING FOR 15 MINUTES WITH SEAT WARMERS ON MY HUSBAND (DRIVER) TURNED IT OFF. WE WERE TRAVELLING ON SUBURBAN ROADS AROUND 40 MPH. THEN AT A STOP LIGHT HE NOTICED A BURNING SMELL. WE CONTINUED DRIVING WHEN LIGHT TURNED GREEN. THEN I NOTICED THE SMELL A FEW SECONDS LATER, SO I OPENED A WINDOW EXPECTING TO FIND SMELL A FIRE NEARBY OR HEAR SIRENS. AT THAT POINT WE SAW A PLOOM OF SMOKE COME FROM UNDER HIS SEAT TOWARDS THE PASSENGER SIDE OPEN WINDOW. HE IMMEDIATELY PULLED OVER, JUMPED OUT OF THE CAR AND TURNED EVERYTHING OFF. THE SMOKE TOOK SOME TIME TO CLEAR BUT DID STOP. SEVERAL MINUTES LATER WE DROVE 1 MILE TO THE BMW DEALERSHIP. WE WERE TOLD ITS NOT UNDER WARRANTY, AND WOULD COST $1,700 TO FIX. I DECLINED TO PAY $1,700 TO FIX AND REQUESTED THEY DISCONNECT SEAT HEATER. BMW PERSONNEL INFORMED ME IT COULD NOT DISCONNECT POWER TO SEAT HEATER WITHOUT DISCONNECTING THE ENTIRE AC/HEAT SYSTEM. THIS IS A PERSONAL SAFETY ISSUE, NOT A WARRANTY ISSUE. FOR A SEAT HEATER TO CAUSE SMOKE IT CAUSED A FIRE AND THIS IS A DEFECT. THE CAR WILL CATCH ON FIRE IF THE SEAT WARMER IS ACTIVATED. I ASKED DEALERSHIP WHAT IF I LOAN MY CAR TO SOMEONE WHO DOES NOT KNOW ABOUT THE DEFECT, THEY SUGGESTED PUTTING TAPE OVER THE BUTTON. THIS IS NOT ACCEPTABLE SAFETY MEASURE TO PREVENT BURNS, FIRE, OR EVEN DEATH. CONSIDER FOR A MOMENT PEOPLE HAVE SMALL CHILDREN THAT RIDE IN THIS VEHICLE. ON A COLD MORNING I COULD HAVE BUCKLED KIDS IN, TURNED ON CAR, SEAT HEATER, AND TALK TO A NEIGHBOR FOR 2 MINUTES, OR TEACHER AT THE CARPOOL LINE.... WHAT WOULD HAVE HAPPENED TO THE CHILDREN? THERE IS NO VISIBLE DAMAGE TO VEHICLE BUT BMW PERSONNEL DID AGREE THERE WAS SMOKE SMELL IN VEHICLE CAUSED BY SEAT WARMER.
JUST PARKED THE VEHICLE, TURNED OFF THE VEHICLE AND SMELLED SOMETHING BURNING. EXITED THE VEHICLE, OBSERVED SMOKE FROM UNDER THE HOOD, OPENED THE HOOD AND OBSERVED FLAMES FROM THE LEFT SIDE OF THE ENGINE, MOSTLY ON THE TOP LEFT OF THE ENGINE NOW. CALLED THE FIRE DEPARTMENT WHO EXTINGUISHED THE FLAMES, AND HAD THE CAR TOWED TO THE DEALER. THE VEHICLE IS NOW IN THEIR LOT WAITING FOR THEIR INVESTIGATORS TO LOOK AT THE VEHICLE. THE FIRST COMMENT OUT OF THE DEALERSHIP, MAYBE AN ANIMAL BUILT A NEST IN THE ENGINE AREA. THIS VEHICLE ONLY HAD 3000 MILES ON IT, PURCHASED IN JUNE OF 2011, AND IS GARAGE KEPT. *TR
INVOLVED IN AN ACCIDENT. OTHER VEHICLE GOING SOUTHBOUND CROSSED OVER MEDIAN STRIP OF HIGHWAY, HIT THREE CARS GOING NORTHBOUND, MINE WAS THIRD CAR TO BE STRUCK. OFFENDING CAR DID A 360 IN FRONT OF ME, I SLOWED TO ABOUT 25 AND HE MOVED INTO ME. I STRUCK HIS REAR PASSENGER SIDE CORNER. I HAD FRONT END DAMAGE OVER $5K. NO AIRBAG, BUT DEFAULT MESSAGES AND AN AIRBAG ICON CAME ON THE VIDEO SCREEN AND THE FRONT INSTRUMENT PANEL. IT STATES "DRIVER AND PASSENGER AIRBAG OR RESTRAINT SYSTEM MALFUNCTION." *JS
I am filing a complaint regarding the recall work performed on my 2011 BMW 528i for the VANOS bolt safety recall. The recall notice stated the vehicle was unsafe to drive until repaired. I arranged towing to Jackie Cooper BMW in Edmond, Oklahoma because of this safety warning. The dealership performed the recall repair and released the vehicle back to me. Immediately after picking it up, the vehicle experienced a failure and became inoperable. The vehicle had to be towed again. This time, the dealership covered the towing cost and had the vehicle returned to my residence. Staff present at the time included a technician named Luke and the Service Drive Manager, Tayler Hawkins. Staff statements indicated that diagnostic charges would have applied if issues outside the recall were found, but no diagnostics were ultimately billed. There were also inconsistencies regarding the availability of the service manager. I am filing this complaint because the vehicle failed immediately after recall service and required towing. I am concerned that the recall work may not have been performed correctly or that the vehicle was released in a condition that was not suitable for operation. I am requesting that this incident be documented as part of the recall and safety record for this vehicle.
The contact owns a 2011 BMW 528I. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
The contact owns a 2011 BMW 528I. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated, and the vehicle stalled. The contact pulled over, and after several attempts, the vehicle restarted. The contact was able to restart the vehicle, and the message "Drivetrain Malfunction" was displayed. The contact stated that the failure started recently and had occurred several times. Additionally, the vehicle was vibrating intermittently and lost motive power. The contact stated that occasionally the vehicle failed to accelerate above 15 MPH. The contact smelled the odor of gasoline inside the vehicle. The contact stated that the check engine warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.
The contact owns a 2011 BMW 528I. The contact received notification of NHTSA Recall Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING), and the vehicle was taken to a local dealer for the recall repair. The contact stated that while driving 40 MPH, the message "Drive Train Malfunction - Drive Moderately" was displayed. The vehicle was towed to the same dealer to be diagnosed. The contact was informed that faulty spark plugs had caused damage to a cylinder, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 123,568.
It feels like someone is hitting me from behind when it downshifts from I believe 2nd into 1st gear. Its a hard down shift. I was told by a mechanic at Bavarian Auto in Bakersfield Ca. His name is Sal and he is the owner. I told him when I took my car in that I wanted the transmission fluid changed. He told me it's a lifetime transmission and it never had to be changed. Now I'm pretty sure I'm having a problem with my transmission because of it needing the oil changed.
The contact owns a 2011 BMW 528I. The contact stated that the vehicle was difficult to start. The vehicle was taken to the dealer and the starter was replaced; however, the failure recurred. The vehicle was taken to an independent mechanic where the starter was replaced; however, the failure persisted. The contact stated that while stopped at a traffic light, the vehicle shut off and failed to restart. The vehicle was towed to Pep Boys to be diagnosed. The vehicle was not diagnosed or repaired. Another dealer, BMW of Tallahassee (1485 Capital Cir NW, Tallahassee, FL 32303); was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 140,000.
on February 1,2025 Pushed the trunk release at Autozone to take battery out of vehicle. And, trunk spring/release was so strong the trunk broke my back windshield again. This would be the second time I've had this happen. the first was on August9.2023. Ever since I've purchased the vehicle the trunk ring/release has been real strong. This really needs to be looked into!
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.