2004 Audi A6
Check a specific vehicle
This page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VINThis page describes the model. To see how one particular car is equipped, and whether its identifier is valid, decode its VIN.
Decode a VIN4 recalls and 35 owner complaints on record for this model year.
Almost all of this describes the model year, not the individual car. Nothing here can tell you about this vehicle’s mileage, accidents or ownership — no identifier encodes those.
TL*THE CONTACT OWNS A 2004 AUDI A6 AVANT. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT HAD BEEN ILLUMINATING INTERMITTENTLY. THE DEALER STATED THAT THE CONTACT SHOULD NOT WORRY ABOUT THE LIGHT. WHILE DRIVING 65 MPH, THE CONTACT SWERVED TO MISS A DEER AND LOST CONTROL OF THE VEHICLE. IT BEGAN TO ROCK BACK AND FORTH AND THE BRAKES WERE INOPERATIVE. THE CONTACT HIT GUARDRAILS ON BOTH THE DRIVER AND PASSENGER SIDES. THE VEHICLE THEN TIPPED ON ITS SIDE AND WENT INTO A RAVINE. THE ENGINE WAS STILL RUNNING AND THE WHEELS WERE STILL SPINNING. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUFFERED INJURIES TO THE COLLAR BONE, RIBS, A CONCUSSION, AND LOST TEETH. THE DEALER STATED THAT THERE COULD HAVE BEEN A PROBLEM WITH THE COMPUTER. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 190,000. UPDATED 04/08/11
TL* THE CONTACT OWNED A 2004 AUDI A6. WHILE DRIVING AT 20 MPH, SMOKE APPEARED FROM THE ENGINE COMPARTMENT AND THE VEHICLE CAUGHT FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V198000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.
TL* THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THAT THERE WAS A FAILURE IN THE ELECTRIC HARNESS UNDER THE PASSENGER SEAT. THE CONTACT STATED THAT HE NOTICED A BURNING ODOR AND THEN THE POWER FAILED TO MOVE THE SEAT. UPON FURTHER REVIEW, THE CONTACT DISCOVERED THAT THE CARPET UNDER THE SEAT WAS SINGED AND HAD MELTED SOME PLASTIC UNDER THE SEAT. THE VEHICLE WAS TAKEN TO THE CONTACT'S PERSONAL MECHANIC WHERE HE WAS INFORMED THAT THE VEHICLE POSED A SAFETY HAZARD AND SHOULD NOT BE DRIVEN. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 04V133000 (ELECTRICAL SYSTEM) AND CONTACTED THE DEALER AND THE MANUFACTURER TO INQUIRE OF THE RECALL CAMPAIGN. THE DEALER AND THE MANUFACTURER BOTH ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 94,648 UPDATED 6/1/12 *CN THE CAUSE OF THE FIRE WAS THE SHORTING OF THE SEAT HARNESS WIRING UNDER THE PASSENGER CARPETING FROM MOVEMENT AND THERE WAS A BEND/ KINK IN THE HARNESS WHEN ASSEMBLED AND THERE WAS SUB DAMAGE TO ADJACENT WIRE HARNESS. UPDATED 06/22/12
- ABS Module has intermittent failures, available for inspection - Anti-lock brakes will not work - Yes, the problem reoccurs and the module loses power and then errors out - Others - VCDS - ABS lights come on and BRAKE light stays illuminated
RE: SAFETY RECALL 20L8/JY; 08V157000: FUEL TANK ROLLOVER VALVE MODIFICATION; VIN: (XX); 2004 AUDI A6 3.0L QUATTRO AT5 ATTACHED DOCS: 1. 20L8/JY RECALL NOTICE. 2. 7.14.2008 & 11.18.18 AUDI N. SCOTTSDALE, AZ DEALER INVOICES 3. AUDI A6 GAS TANK DIAGRAM. AUDI CORP EMAIL RESPONSE: "AT THIS TIME WE HAVE IDENTIFIED THAT THE 20L8 REPAIR WAS SPECIFIC TO THE DRIVER'S SIDE OF THE VEHICLE. THE DEALERSHIP IS INDICATING THIS CURRENT RECOMMENDED REPAIR IS SPECIFIC TO THE PASSENGER SIDE OF THE VEHICLE." "SINCE WE ARE SHOWING THE 20L8 COMPLETED IN JULY OF 2008 AND THE ORIGINAL 20L8 REPAIR IS SPECIFIC TO DRIVER'S SIDE ROLLOVER NIPPLE VALVES, ACCORDING TO THE DEALERSHIP THIS CURRENT REPAIR IS UNRELATED TO THE RECALL." "CURRENTLY PER THE NHTSA WEBSITE, THE 20L8 IS NOT SHOWING AS AN OPEN RECALL, SO I WOULD BE UNABLE TO SPEAK TO HOW THEY WOULD REACT TO INFORMATION REGARDING A CLOSED RECALL." 'WE HAVE NO EVIDENCE SUPPORTING AN INCORRECT REPAIR BEING PERFORMED IN JULY OF 2008, SO AT THIS TIME WE WOULD BE UNABLE TO PROVIDE ASSISTANCE TOWARDS THIS REPAIR." CURRENT EMISSIONS CHECK ENGINE LIGHT (NOV 18, 2018) IS DIAGNOSED BY THE AUDI DEALER AS A GAS TANK LEAK. ALSO, THERE IS A STRONG ODOR COMING FROM GAS TANK. DEALER QUOTED TO REPLACE THE ENTIRE TANK (SEE ATTACHED #2). THERE ARE SEVERAL ROLLOVER VALVES ON EACH SIDE OF THE GAS TANK ON THE TOP SIDE (SEE ATTACHED #3 GAS TANK DIAGRAM). RECALL (SEE ATTACHED #1) DOES NOT ADDRESS "DRIVERS SIDE OR PASSENGER SIDE" OF GAS TANK. DEALER CLAIMED THAT BACK IN 2008 THAT THEY DID NOT EVEN LOWER THE GAS TANK FOR THE REPAIR. IN SUMMARY: MY VEHICLE CURRENTLY HAS A GAS TANK LEAK ON TOP OF THE GAS TANK COMING FROM THE ONE OR MORE ROLLOVER VALVE NIPPLES ON TOP OF THE GAS TANK. THE SAFETY RECALL ADDRESSES REPAIRING AND REINFORCING THESE LEAKING ROLLOVER VALVE NIPPLES SO A REPAIR REQUEST SHOULD BE COVERED BY THE RECALL. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
AFTERMARKET RADIO: PIONEER ELECTRONICS AVH-4100 NEX BACKUP CAMERA FAILS AND DISTRACTS DRIVER SIGNIFICANTLY. I HAVE ATTACHED A SCAN OF THE COMPLAINT TO PIONEER ELECTRONICS. THE RADIO LIKELY HAS SOFTWARE DEFECT THAT CAUSES VERY DISTRACTING FAILURES WHEN OPERATING THE BACK-UP CAMERA. PIONEER ADVERTISES THAT THIS BACKUP CAMERA WORKS AS ADVERTISED - IT IS ACTUALLY NOW A DISTRACTION AND HAZARD. AS WELL, OPERATING GOOGLE "ANDROID AUTO" CAUSES MORE SIGNIFICANT DRIVING DISTRACTIONS WHEN USING THE BACKUP CAMERA FUNCTION OF THE AVH-4100. COMPLAINTS TO PIONEER ELECTRONICS HAVE BEEN FRUITLESS. THEY SEEM TO BE ARROGANT AND CLAIM: "ALL OF OUR PRODUCTS ARE THOROUGHLY TESTED." I WOULD LIKE PIONEER ELECTRONICS TO FIX THE SOFTWARE ISSUE AND CREATE A NEW RELEASE THAT ALLOWS THE BACKUP CAMERA TO WORK WITHOUT A DISTRACTION AND SAFTY-HAZARD.
WHEN ENGINE IS COLD, USUALLY BELOW 0 DEGREES FUEL SPRAYS FROM INJECTORS. THIS COULD IGNITE ON EXHAUST MANIFOLDS CAUSING CAR FIRE.
WITH THE ELEC STABILITY CONTROL BEING INTERMITTENT THIS IS BEING CAUSED BY THE ABS MODULE GOING BAD/INTERMITTENT THE BRAKE PEDAL PRESSURE CHANGES. I HAVE EXPERIENCED THIS WITH MY 2002 RAM 1500 (4X4) AS WELL. THIS COULD BE A PROBLEM IN ALL CARS AND TRUCKS. THE COST THE FIX FOR AN AUDI IS AROUND $2500.00 AND MY RAM WAS $1300.00. *TR
TL*THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, A STRONG ODOR OF GASOLINE EMITTED INSIDE AND AROUND THE VEHICLE. THE CONTACT MENTIONED THAT THE CHECK ENGINE LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE FUEL TANK COLLAPSE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 146,569.
THE FIRST THROTTLE VALVE MALFUNCTION HAPPENED ON JULY 2013. COST TO REPAIR 1557.95 PART COST 878.00 MILEAGE 66784 THE SECOND MALFUNCTION HAPPENED ON OCT. 14, 2014 TO REPAIR 1200.00 PART COST 913.00, MILEAGE 69202 WHAT HAPPENS HERE IS THE ENGINE SHUTS DOWN. THERE COULD HAVE BEEN E MAJOR ACCIDENT IF SHE WAS REAR ENDED. I CALLED AUDI TO TELL THEM THE PART WAS DEFECTIVE, BUT THEY WOULD NOT LISTEN. THAT IS WHY I THINK THERE SHOULD BE A RECALL, TO SEND THEM A MESSAGE. *TR
SIGNIFICANT GAS LEAK CAUSED BY BROKEN GAS "IN TANK SENDING UNITS" HOUSING AND SEAL. GAS WILL LEAK AND FILL THE INSIDE OF THE CAR WITH FUMS AS WELL AS UNDER THE CAR. REPLACEMENT REQUIRED BUYING A REVISED DESIGN SENDING UNITS THAT INCLUDE ALL THREE SENDING UNITS. THE PRICE IS HIGH ~$500 AND THE CONSEQUENCES VERY DANGEROUS. MY CAR IS: 2004 AUDI A6 [XXX] 2004 A6Q 2.7T INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
REPLACED CYLINDER BANK 1 RIGHT SIDE! *TR
PASSENGER SIDE MECHANICAL VERTICAL ADJUSTER DOES NOT FUNCTION IS LAMP POINT TO ABOUT 10 FEET TO THE FRONT OF THE VEHICLE. DIVER SIDE ADJUSTER APPEAR TO FUNCTION OK. ONLINE BLOGS CONFER MULTIPLE PROBLEMS WITH AUDI HEADLIGHT ADJUSTERS AS COMMON, RECURRENT, AND COSTLY TO FIX. DRIVING WITH POORLY AIMED LIGHTS IS OBVIOUSLY SAFETY ISSUE. *TR
TL*THE CONTACT OWNS A 2004 AUDI A6. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE OVER THE THREE QUARTER CAPACITY LEVEL, A SUBSTANTIAL AMOUNT OF FUEL WOULD LEAK UNDERNEATH THE VEHICLE NEAR THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THE FUEL TANK ROLLOVER VALVE WAS LEAKING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED SIGNIFICANT CONCERN OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.
2004 AUDI A6 SEDAN, 3.0 ENGINE DEVELOPED A SUDDEN LOSS OF POWER JUST BEFORE VEHICLE STALLED WHILE DRIVING ON HIGHWAY AT 65 MPH. VEHICLE WAS TOWED TO REPAIR SHOP WHERE IT WAS DETERMINED THAT THE FUEL PUMP HAD FAILED. *TR
Filed by owners of this model year and unverified by NHTSA — one person’s account, not an established fact.
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2001-2004 AUDI A6, MODEL YEAR 2002-2003 S6 AND MODEL YEAR 2003 RS6 VEHICLES EQUIPPED WITH 4.2L ENGINES AND MANUFACTURED FROM JUNE 19, 2001, THROUGH JUNE 8, 2004. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.
Remedy: DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.
Remedy: DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.
ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.
Published by model year, not by VIN — may not apply to this vehicle, or may already have been done. Confirm with a dealer.
The product has a defect in the buckle and the anchorage of the seat belt, which may result in insufficient restraining effect of the seatbelt, increasing the risk of injuries, in particular to the passengers of the front seats. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The high-voltage battery’s cell modules could overheat during charging. This may lead to fire. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
If the front passenger airbag is deployed as a result of an accident, the gas generator housing may burst or components of the gas generator housing may come loose and cause serious or fatal injuries to vehicle occupants. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The torsion bar is defective and may easily break, leading the belt strap to unwind uncontrollably in the event of an accident. The protective effect of the seat belt would therefore no longer be assured which can lead to injury. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The vehicles may have been fitted with a damaged module of the passengers airbag, which may impair the restraining effect of the airbag in the event of an accident, posing a risk of injury. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
During the charging process, the high/voltage battery may overheat due to a defect in the battery modules. This can result in a fire and cause injuries to occupants and bystanders. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
The front left side airbag is not properly fixed and the seat may cause the area covered by the airbag to move slightly. As a result, the protective effect of the airbag is reduced, increasing the risk of injury in case of an accident. The product does not comply with the Regulation on the approval and market surveillance of motor vehicles and their trailers, and of systems, components and separate technical units intended for such vehicles.
Matched on brand and model name — Safety Gate publishes no VIN. Check the production dates, and quote the recall code to a dealer.